fibre and shell fired boiler manufacturer in Israel

Details


  • Production capacity: 7-70 MW
  • Work pressure: 1.0-1.6 Mpa
  • Applicable fuel: Nature gas, coke oven gas, blast furnace gas, carbon black off-gas, biogas, methanol, etc.
  • Applicable industry: heat suppling, hospital, colleges and universities.


Product introduction

  SZS Series Boiler is double drums, longitudinal arranged, "D" type chamber structure. Furnace is on right side and convection tube bundle is on the left. The body is fixed on the basement by middle and both end flexible supports and make the boiler to expand horizontally to sideways. Around furnace is membrane water cooling tube wall. Furnace and tube bundle is totally separated by the membrane water tube cooling wall at the left side of the furnace. The back part of bundle is sparse shift structure, front part is aligned structure. Smoke from furnace outlet enters re-burning chamber, bundle area, and then from left front part enters spiral fin coil economizer and condenser, finally discharged to atmosphere through chimney.





Safety

  Boiler body high temperature area adopt forced circulation to make sure each part heating area can be cooled down and avoid vaporization;

  Boiler has explosion door and flame detector for safe and reliable operation.

  comb plates are used as the sealing between both sides of boiler and tube bundle all use to avoid leakage of condensate and gas which is caused by refractory concrete sealing.

  air tightness test is done before leaving the factory to ensure no leakage of gas.

environmental protection

  Bigger combustion chamber and Low emission combustion engine to reduce the NOX to 30mg/Nm3

  Smoke duct and smoke outlet has internal insulation to reduce operating noise.

  Combustion chamber use full membrane water cooling wall structure, pressurized firing without smoke mixture.

energy conservation

  Good quality alumina silicate fiber and fire clay insulation is used, boiler body temperature is controlled below 45℃, to reduce heat lost.

  Combustion chamber use narrow distance tube membrane water cooling wall which has good air tightness, and reduce heat lost and increase boiler thermal efficiency.

  Inside of Inspection holes use high-alumina refractory and man hole cover sealing devices, it solved the high temperature of this part by using refractory brick

Convenience

  Thera are manholes on front and back side of both bundle and inspection doors on back side of boiler, which are easy to open for inspection and cleaning inner part.

longer lifespan

  Membrane structure of Front and back wall is used for boiler body, which highly increased their lifespan to over 20 years.

  The key part such as material cutting, rolling, drilling are proceeded by advanced CNC machining process to reduce the assemble stress and extend boiler working lifetime.

  flutter prevention fastener is used for high temperature part convection tube, which avoid bundle tube cracking problem.

  Longitudinal and girth joint adopt advanced automatic submerged-arc welding for good welding quality. All longitudinal and girth joint will have 100% radiographic inspection.

 
Items
Model
SZS7-1.0/115/70-Q SZS10.5-1.0/115/70-Q SZS14-1.25/115/70-Q SZS17.5-1.25/115/70-Q SZS21-1.25/130/70-Q SZS29-1.25/130/70-Q SZS46-1.6/130/70-Q SZS58-1.6/130/70-Q SZS70-1.6/130/70-Q SZS116-1.6/130/70-Q
Rated thermal power(MW) 7.0 10.5 14.0 17.5 21.0 29 46 58 70 116
Rated working pressure(MPa) 1.0 1.0 1.25 1.25 1.25 1.25 1.6 1.6 1.6 1.6
Rated output water temperature(℃) 115 115 115 115 130 130 130 130 130 130
Rated Feeding water temperature(℃) 70 70 70 70 70 70 70 70 70 70
Heating area(㎡) Main body(㎡) 168.0 220.0 245.30 284.40 394.75 428.1 1065.9 1225.7 1408.4 6164.8
Condenser (㎡) 164.0 306.0 527.0 645.1 738.3 990.8 985.3 1292.5 1642.1 1830
Available fuel Natural gas, biogas, coke oven gas, light oil, methanol, biodiesel etc
Gas consumption(Nm³/h) 720 1080 1440 1800 2160 2982 4680 5760 7200 11880
Thermal efficiency(%) >98 >98 >98 >98 >98 >98 >98 >98 >98 >98
MAX.transportation weight(t) 42.0 48.0 52.5 57.5 65.0 72.5 散件12.6 散件13.8 散件16 散件20
MAX. transportation dimension LxWxH(m) 7.87x3.40x3.34 8.85x3.85x3.93 8.51x3.85x3.75 9.31x3.77x3.75 10.10x4.13x4.15 10.90x4.13x4.15 11.00xΦ1.45 11.10xΦ1.46 12.00xΦ1.66 12.50xΦ1.66

CONTACT FORM



Alfa Laval DCH DCH can be supplied with different fan diameters (1250 up to1440 mm) fitted with fan blades in aluminium (wind profile), fiber glass or galvanized steel. Coal Fired Boilers Husk Fired Service Provider Service Provider of Coal Fired Boilers, Husk Fired, Agrowaste Fired Boiler, Fluidised Bed Bed Steam Boiler,with its experience of more than 3 decades in design, manufacturer and . saw dust, coconut shellGuaranteed rated steam Fluidised Bed Steam Boilers output with High-tech Ceramic Fibre Blanket Insulation. ISRAELI INDUSTRY OIL AND GAS CATALOGUE Jun 15, 2015 develop an Israeli knowledge-based supplier industry integrated into the oil this catalogue include: 3D imaging, EO/IR detectors, fiber-based Changes in the Fuel Pellet Industry in the Lake In 2005, 41% of the fiber feed stock used to produce pellets in the Lake States and other nations that supported Israel during the Yom Kippur War (Jordan et al. for boiler fuel and is less expensive to manufacture than standard-grade pellets . logging residue, seed shells, corn stocks, wastepaper, and nearly any other Alfa Laval M line CIP (Cleaning-In-Place) heating. Alfa Laval FrontLine is recommended for more heat sensitive products or for products containing pulp and fibres. programme The 10th Conference on Sustainable SDEWES2015-0349 PYROLYSIS OF PINE SHELLS AND WHEAT STRAW: .. Economical-Environmental Assessment of Wind Power Generation in Israel SDEWES2015-0268 Balanced Manufacturing a methodology for energy efficient . OF COAL-FIRED UTILITY BOILER PERFORMANCE BEFORE AND AFTER Palm Kernel Shells as Biomass Resource BioEnergy Dec 18, 2015 Press fibre and shell generated by the palm oil mills are traditionally used Dual -fired boilers capable of burning either diesel oil or natural gas are the . We are Ghana based Importer/Exporter and Supplier s of all kinds of Empty Fruit Bunches biomass CFB boiler in Nigeria 2 days ago Most of the electricity produced is from gas fired thermal power plants and product of the processing; EPF bunch, fibre and shell are always Why choose ZOZEN Boiler as Empty Fruit Bunches biomass CFB boiler in Nigeria manufacturer Mid East(Bahrain, Egypt, Iran, Iraq, Israel, Jordan, Kuwait, Lebanon, Industrial Tube Boilers Vertical Cross Tube We offer oil fired boilers that are available with all-welded construction, of 3 pass, Shell insulated with fibre glass wool mattresses reducing loss by radiation. Alfa Laval BaseLine CIP (Cleaning-In-Place) heating. Alfa Laval FrontLine is recommended for more heat sensitive products or for products containing pulp and fibres. Non IBR Steam Boiler Technomax Engineering Co. ENGINEERING CO. Exporter, Manufacturer, Service Provider Supplier of Non IBR Steam Boiler based in Mumbai, India. Thermal fibre insulation is provided on the outer casing. The exterior Drawbacks of downward firing has been eliminated by ingeniously placing the burner almost midway of the vertical shell. Alfa Laval FrontLine Clip plate WideStream The Clip plate WideStream has a wider plate pattern with fewer contact points which makes it ideal for products containing pulp or fibres Thermax Packaged-Boilers Dieffenbacher GmbH, the German OEM is also the technology supplier for Greenplys MDF unit. Traditionally energy Shell Boiler. Oil/Gas Fired. Shellmax alfa-laval-wins-sek-50-million-food-order-in-india Nov 3, 2015 The order comprises the delivery of a complete process line for refining de-oiled soy seed into vegetable protein, sugar concentrates and fiber Products | The Flexitallic Group They are suitable for replacing aramid, glass, and carbon fiber; PTFE; and graphite heat exchangers, boiler handholes, manholes, and other high- temperature, calendared sheet materials made using traditional manufacturing techniques. a metallic outer shell with either metallic or non-metallic compressed fiber filler. Alfa Laval Tube-in-tube heat exchangers Designed specifically for heating and cooling of sludge containing fibres and The shell tube is always smooth while the product tube is either corrugated or Portland Kettle Works: Craft Brewery Equipment Micro brew systems with fire or steam power. Portland Kettle Works is a family owned, Brewery Manufacturer that designs, engineers and fabricates World Simulation and Thermal Analysis of the Effect of Apr 20, 2007 In stoker-firing furnaces, possible conditions created by adverse characteristics are Study of Biomass Combustion in a Thermal 108 MW Grate-Fired Boiler B . Zapata , J. Balmaseda , E. Fregoso-Israel , E. Torres-García Spontaneously formed shell on microscopic alloy droplets keeps them in liquid Destroyer Wikipedia, the free encyclopedia This was a large (137 ton) torpedo boat with four 47 mm quick-firing guns and type of ships equipped with the then novel water-tube boilers and quick-firing small calibre guns. .. 130 mm automatic naval guns which can fire laser-guided shells. . Israeli Navy is due to receive two Sachsen-class frigates from Germany chain grate boiler,horizontal chain grate steam DZL series horizontal chain grate steam boiler which is a horizonal type with a Chain grate steam boiler for sale fuel: coal, biomass, cotton stalk,groundunt shell, palm fibre, WNS3-1.0-Y horizontal gas fired boiler for sale is fire tube boiler, with Mid East(Bahrain, Egypt, Iran, Iraq, Israel, Jordan, Kuwait, Lebanon, Oman ,