coal utility boiler

Details


  • Production capacity: 7-70 MW
  • Work pressure: 1.0-1.6 Mpa
  • Applicable fuel: Nature gas, coke oven gas, blast furnace gas, carbon black off-gas, biogas, methanol, etc.
  • Applicable industry: heat suppling, hospital, colleges and universities.


Product introduction

  SZS Series Boiler is double drums, longitudinal arranged, "D" type chamber structure. Furnace is on right side and convection tube bundle is on the left. The body is fixed on the basement by middle and both end flexible supports and make the boiler to expand horizontally to sideways. Around furnace is membrane water cooling tube wall. Furnace and tube bundle is totally separated by the membrane water tube cooling wall at the left side of the furnace. The back part of bundle is sparse shift structure, front part is aligned structure. Smoke from furnace outlet enters re-burning chamber, bundle area, and then from left front part enters spiral fin coil economizer and condenser, finally discharged to atmosphere through chimney.





Safety

  Boiler body high temperature area adopt forced circulation to make sure each part heating area can be cooled down and avoid vaporization;

  Boiler has explosion door and flame detector for safe and reliable operation.

  comb plates are used as the sealing between both sides of boiler and tube bundle all use to avoid leakage of condensate and gas which is caused by refractory concrete sealing.

  air tightness test is done before leaving the factory to ensure no leakage of gas.

environmental protection

  Bigger combustion chamber and Low emission combustion engine to reduce the NOX to 30mg/Nm3

  Smoke duct and smoke outlet has internal insulation to reduce operating noise.

  Combustion chamber use full membrane water cooling wall structure, pressurized firing without smoke mixture.

energy conservation

  Good quality alumina silicate fiber and fire clay insulation is used, boiler body temperature is controlled below 45℃, to reduce heat lost.

  Combustion chamber use narrow distance tube membrane water cooling wall which has good air tightness, and reduce heat lost and increase boiler thermal efficiency.

  Inside of Inspection holes use high-alumina refractory and man hole cover sealing devices, it solved the high temperature of this part by using refractory brick

Convenience

  Thera are manholes on front and back side of both bundle and inspection doors on back side of boiler, which are easy to open for inspection and cleaning inner part.

longer lifespan

  Membrane structure of Front and back wall is used for boiler body, which highly increased their lifespan to over 20 years.

  The key part such as material cutting, rolling, drilling are proceeded by advanced CNC machining process to reduce the assemble stress and extend boiler working lifetime.

  flutter prevention fastener is used for high temperature part convection tube, which avoid bundle tube cracking problem.

  Longitudinal and girth joint adopt advanced automatic submerged-arc welding for good welding quality. All longitudinal and girth joint will have 100% radiographic inspection.

 
Items
Model
SZS7-1.0/115/70-Q SZS10.5-1.0/115/70-Q SZS14-1.25/115/70-Q SZS17.5-1.25/115/70-Q SZS21-1.25/130/70-Q SZS29-1.25/130/70-Q SZS46-1.6/130/70-Q SZS58-1.6/130/70-Q SZS70-1.6/130/70-Q SZS116-1.6/130/70-Q
Rated thermal power(MW) 7.0 10.5 14.0 17.5 21.0 29 46 58 70 116
Rated working pressure(MPa) 1.0 1.0 1.25 1.25 1.25 1.25 1.6 1.6 1.6 1.6
Rated output water temperature(℃) 115 115 115 115 130 130 130 130 130 130
Rated Feeding water temperature(℃) 70 70 70 70 70 70 70 70 70 70
Heating area(㎡) Main body(㎡) 168.0 220.0 245.30 284.40 394.75 428.1 1065.9 1225.7 1408.4 6164.8
Condenser (㎡) 164.0 306.0 527.0 645.1 738.3 990.8 985.3 1292.5 1642.1 1830
Available fuel Natural gas, biogas, coke oven gas, light oil, methanol, biodiesel etc
Gas consumption(Nm³/h) 720 1080 1440 1800 2160 2982 4680 5760 7200 11880
Thermal efficiency(%) >98 >98 >98 >98 >98 >98 >98 >98 >98 >98
MAX.transportation weight(t) 42.0 48.0 52.5 57.5 65.0 72.5 散件12.6 散件13.8 散件16 散件20
MAX. transportation dimension LxWxH(m) 7.87x3.40x3.34 8.85x3.85x3.93 8.51x3.85x3.75 9.31x3.77x3.75 10.10x4.13x4.15 10.90x4.13x4.15 11.00xΦ1.45 11.10xΦ1.46 12.00xΦ1.66 12.50xΦ1.66

CONTACT FORM



coal-fired utility boilers: solving ash deposition problems OSTI primarily with coal-fired utility boilers and is an interim document, which visual observation of ash deposition types or by boiler-monitoring devices or controls. Control of Mercury Emissions from Coal-fired Electric Utility Boilers FROM COAL-FIRED ELECTRIC UTILITY BOILERS. Air Pollution Prevention and Control Division. National Risk Management Research Laboratory. Office of Coal-Water Slurry as a Utility Boiler Fuel Annual Reviews COAL-WATER SLURRY AS A UTILITY BOILER FUEL. 27 coal (less than 0.5 wt% ash); 5. firing coal-derived synthetic liquid fuels;. 6. conversion to coal/liquid evaluation of coal-derived liquids as utility boiler fuels-eastern test. (EPRI) under project RP 2112. to assess the potential of coal derived. liquid syn- gentially-fired utility boiler, a combustion turbine and diesel piston engines. Nitrogen oxides emission control options for coal-fired electric utility J Air Waste Manag Assoc. 2005 Sep;55(9):1367-88. Nitrogen oxides emission control options for coal-fired electric utility boilers. Srivastava RK(1), Hall RE, evaluation of coal-derived liquids as utility boiler fuels-eastern test. (EPRI) under project RP 2112. to assess the potential of coal derived. liquid syn- gentially-fired utility boiler, a combustion turbine and diesel piston engines. FEASIBILITY AND COST OF CONVERTING OIL- AND COAL-FIRED oil or coal in existing utility boilers would reduce emissions of sulfur and thereby the and coal fired utility boilers to burn intermittently natural gas and the. Texas Utility to Idle Boilers, Coal Mines in Response to New EPA Rule Sep 12, 2011 Luminant, the largest electricity producer in Texas, announced this morning that it will shut down two of its coal-fired boilers and close three Gas Cofiring Assessment for Coal Fired Utility Boilers EPRI Exact Match Gas Cofiring Assessment for Coal Fired Utility Boilers. Product ID: 1000513. Published: 23-Aug-2000. Type: Technical Results. Pages: 275. Natural Gas Conversions of Existing Coal-fired Boilers (MS-14) Electric utilities are always searching for ways to mini- mize costs For those utilities with existing coal-fired units, conversion from coal firing to natural gas. Plasma assisted power coal combustion in the furnace of utility Plasma assisted power coal combustion in the furnace of utility boiler: Numerical modeling and full-scale test. V.E. Messerlesup,/sup,; E.I. Karpenko,; A.B. Ustimenkosup, ,/sup. Coal-Water Slurry as a Utility Boiler Fuel Annual Review of Energy Coal-Water Slurry as a Utility Boiler Fuel Low-Rank Coal: Its Present and Future Role in the United States. E A Sondreal, and G A Wiltsee. Annual Review of Boilers for steam power plants Alstom Power GE Power Why choose Alstom utility boilers? Take advantage of tower type boiler. Pulverised coal tower type boiler: market leading boiler technology for all types of coal. Challenges when Converting Coal-Fired Boilers to Natural Gas When evaluating the prospect of converting a coal-fired boiler to natural gas, is a very flexible and consistent fuel that allows for industrial and utility burners to. Low-oxygen enrichment in coal-fired utility boilers CiteSeer Low-oxygen enrichment in coal-fired utility boilers. Ovidiu Marin, Fabienne Chtel-Plage, M. Usman Ghani and Nicolas Perrin. Air Liquide. Chicago Research